Product ID:A-788 SPLASH ZONE CMPD,PART A,B (NEW FORM)
MSDS Date:01/01/1987
FSC:8010
NIIN:00N008374
MSDS Number: BCQBS

KOPPERS CO., INC.

Emergency Phone: 1-800-553-5631

Cage: 6V069

KOPPERS CO., INC.

PITTSBURGH, PA 15219 US

Telephone: (412) 227-2000

Cage: 6V069

EPOXY RESIN

Fraction By Weight: < 25%

IRON OXIDE,AS FUME (CAS# 1309-37-1 (OSHA PEL=10 MG/CUM)

RTECS: JN0740000

Fraction By Weight: < 5%

ACGIH TLV: 5 MG(FE)/CUM

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: < 65%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

2,4,6 TRIS(DIMETHYLAMINO)METHYL PHENOL (CAS# 90-72-2)(TLV

CAS: 90-72-2

RTECS: SN3500000

Fraction By Weight: < 2%

ACGIH TLV: 5 PPM

Effects of Overexposure:EYE:IRRIT,CORNEAL
DMG.SKIN:IRRIT,DERMATITIS,SENSIT.INHAL:RESP TRACT IRRIT.IRON OXIDE
(SEE SUPP DATA)

First Aid:EYE:FLUSH W/H*20 FOR 15 MIN.SKIN:WASH W/SOAP,H*20.WASH CONTAM
CLTHG BEFORE REUSE.INHAL:RMV FROM EXP.IF NOT BRTHG/DIFF,GIVE ARTF
RESP/O*2.INGEST:DONT INDUCE VOMIT.GIVE 1-2 GLASSES MILK.IN ALL
CASES,CAL L DR.NO SPECIFIC ANTIDOTE FOR OVEREXP,TREAT SYMP.

Flash Point:A:> 400F; B:> 3F
Extinguishing Media:DRY CHEM,CO*2,FOAM/H*20 SPRAY(H*20/FOAM MAY CAUSE
FROTHING).
Fire Fighting Procedures:FULL-FACE SCBA,FULL PROT EQUIP.COOL FIRE EXP
CNTNRS W/H*20.
Unusual Fire/Explosion Hazard:IF HEAT,TOXIC VAP/DECOMP PROD
RELEASED,FORM FLAM/EXPLO MIX IN AIR.CLSD CNTNR MAY EXPLODE IF
HEATED.

Spill Release Procedures:STOP LEAK IF NO RISK.STAY UPWIND.SMALL
SPILL:TAKE UP W/SAND OR OTHR NONCOMBUST ABSORBENT MATL.FLUSH AREA
W/H*20.LGE SPILL:DIKE FOR LATER DISPOSAL.CONTAIN RUNOFF FROM FIRE
CONTROL,DILUTION H*20.SPECIAL PROC POSS REQUIRED TO RMV RESINS
AFTERSPILLS.

Handling and Storage Precautions:KEEP IN CLSD CNTNR IN COOL,WELL
SHADED,DRY VENTED AREA.PROT FROM PHYSICAL DMG.READ MFR PRECAUT
BEFORE USE.WASH AFTER USE.AVOID BRTHG VAP,MIST/FUME.
Other Precautions:AVOID SKIN/EYE CONTACT.USE EYE PROT IF WEAR CONTACT
LENS.PROD IS 2 PART KIT,ANY MIX OF PART A + B HAS HAZ OF BOTH
PARTS.PROD REFORMULATED FEB 1986. SPEC GRAVITY:A:1.8149;B:1.6827.
DOP:8/86.

Respiratory Protection:NIOSH/MSHA APPROVED RESP PROT DEPENDING ON
CONDITION OF USE.
Ventilation:GENL/LOCAL EXHAUST VENT.LOCAL EXH NECESS IN ENCLSD/CONF
AREA
Protective Gloves:NEOPRENE
Eye Protection:CHEM GOGGLES + FACE SHLD
Other Protective Equipment:IMPERVIOUS HEAD/NECK
COVER,APRON,JACKET,PANTS,COVERALL,BOOTS
Supplemental Safety and Health
FUME/DUST-PNEUMOCONIOSIS,PULM FUNCT CHANGE.TALC-TALCOSIS,PLEURAL
THICKENG.COUGH,SHORT BREATH POSS.INGEST:NAUSEA,VOMIT,DIARRHEA.IF
PRE-EXIST RESP SYS,SKIN/EYE PROB-GREATER ADVERSE HLTH EFT RISK

Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS PASTE;MIX GREEN(PART A YELLOW,PART B BLACK
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO +/OR C0*2,ALDEHYDES,NITROGEN OXIDES
+ OTHER ORGANICS.

Waste Disposal Methods:PRODUCT IS USEPA DEFINED EP TOXIC WASTE.DISPOSE
OF AS EP TOXIC WASTE IAW LOCAL,STATE & FEDERAL REGULATIONS.PLACE IN
TIGHTLY SEALED LABELED CNTNR.REPORT TO NATIONAL RESPONSE
CENTER(800-424-8802) IF REL EASED INTO ENVIRONMENT (ONE POUND OR
MORE).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.